Studies on optimization of removal of orange G from aqueous solutions by a novel nano adsorbent, nano zirconia

Deepak Gusain; Shikha Dubey; Siddh Nath Upadhyay; Chih H. Weng; Yogesh C. Sharma

Journal of Industrial and Engineering Chemistry, Vol.33, 42-50, January, 2016

DOI10.1016/j.jiec.2015.08.028 Export Citation

Studies on optimization of removal of orange G from aqueous solutions by a novel nano adsorbent, nano zirconia

Deepak Gusain, Shikha Dubey, Siddh Nath Upadhyay¹, Chih H. Weng², and Yogesh C. Sharma^†

Department of Chemistry, Indian Institute of Technology (Banaras Hindu University) Varanasi, Varanasi 221 005, India
¹DAE Raja Ramanna Fellow, Department of Chemical Engineering and Technology, Indian Institute of Technology (Banaras Hindu University) Varanasi, Varanasi <postal>221 005, India
²Department of Civil and Ecological Engineering, I Shou University, Kaohsiung 84008, Taiwan

E-mail:

A nanoadsorbent, nano zirconia was investigated for the removal of Orange G from aqueous solutions. Optimization was carried out via Box-Behnkehn Design and one variable at a time design. The parameters namely initial concentration (50-100 ppm), pH (2 to 6), and adsorbent dose (2 to 10 g/L) at 30 ℃ were optimized by BBD. The following conditions were pointed out by OVAT: pH = 2, initial concentration = 50 ppm and adsorbent dose = 2 g/L. The response surface methodology results for pH and initial concentrations were the same as that obtained by OVAT but were different for adsorbent dose.

Keywords:Adsorption;Nano zirconia;OVAT;Removal;RSM

[References]

Liu T, Li Y, Du Q, Sun J, Jiao Y, Yang G, Wang Z, Xia Y, Zhang W, Wang K, Zhu H, Wu D, Colloids Surf. B: Biointerfaces, 90, 197 (2012)
Atia AA, Donia AM, Al-Amrani WA, Chem. Eng. J., 150(1), 55 (2009)
Fiorentin LD, Trigueros DEG, Modenes AN, Espinoza-Quinones FR, Pereira NC, Barros STD, Santos OAA, Chem. Eng. J., 163(1-2), 68 (2010)
Lau WJ, Ismail AF, Desalination, 245(1-3), 321 (2009)
Sandeman SR, Gun'ko VM, Bakalinska OM, Howell CA, Zheng YS, Kartel MT, Phillips GJ, Mikhalovsky SV, J. Colloid Interface Sci., 358(2), 582 (2011)
Mui ELK, Cheung WH, Valix M, McKay G, J. Colloid Interface Sci., 347(2), 290 (2010)
Liu F, Chung S, Oh G, Seo TS, ACS Appl. Mater. Interfaces, 4, 922 (2011)
Mittal A, Thakur V, Gajbe V, Environ. Sci. Pollut. Res., 19, 2348 (2012)
Huang XX, Qiu LG, Zhang W, Yuan YP, Jiang X, Xie AJ, Shen YH, Zhu JF, Cryst. Eng. Commun., 14, 1613 (2012)
Bai S, Shen X, Zhong X, Liu Y, Zhu G, Xu X, Chen K, Carbon, 50, 2337 (2012)
Khattri SD, Singh MK, Environ. Prog. Sustainable Energy, 31, 435 (2012)
Bhattacharyya R, Ray SK, J. Ind. Eng. Chem., 20(5), 3714 (2014)
Ghaedi M, Ghaedi AM, Hossainpour M, Ansari A, Habibi MH, Asghari AR, J. Ind. Eng. Chem., 20(4), 1641 (2014)
Javadian H, Angaji MT, Naushad M, J. Ind. Eng. Chem., 20(5), 3890 (2014)
Sahoo S, Uma, Banerjee S, Sharma YC, Desalin. Water Treat., 52, 6703 (2014)
Zhang Z, O’Hara IM, Kent GA, Doherty WOS, Ind. Crop. Prod., 42, 41 (2013)
Venkatesha TG, Viswanatha R, Nayaka YA, Chethana BK, Chem. Eng. J., 198-199, 1 (2012)
Luo KQ, Zhou SX, Wu LM, Thin Solid Films, 517(21), 5974 (2009)
Manicone PF, Iommetti PR, Raffaelli L, J. Dent., 35, 819 (2007)
Montgomery DC, Design and Analysis of Experiments, seventh ed., Wiley, New Delhi, 2012.
Anupam K, Dutta S, Bhattacharjee C, Datta S, Chem. Eng. J., 173(1), 135 (2011)
Aydin YA, Aksoy ND, Chem. Eng. J., 151(1-3), 188 (2009)
Gusain D, Srivastava V, Singh VK, Sharma YC, Mater. Chem. Phys., 145(3), 320 (2014)
Singh J, Uma S, Banerjee D, Gusain Y, Sharma C, J. Appl. Sci. Environ. Sanit., 6, 317 (2011)
Singh J, Uma, Banerjee S, Sharma YC, Int. Rev. Chem. Eng., 4, 1 (2012)
Sharma YC, Srivastava V, Weng CH, Upadhyay SN, Can. J. Chem. Eng., 87(6), 921 (2009)
Guo GY, Chen YL, J. Solid State Chem., 178, 1675 (2005)
Goharshadi EK, Hadadian M, Ceram. Int., 38, 1771 (2012)
Deshmane VG, Adewuyi YG, Microporous Mesoporous Mater., 148, 88 (2012)
Tyagi B, Sidhpuria K, Shaik B, Jasra RV, Ind. Eng. Chem. Res., 45(25), 8643 (2006)
Sahu HR, Rao GR, Bull. Mat. Sci., 23, 349 (2000)
Langmuir I, J. Am. Chem. Soc., 40, 1361 (1918)
Xu S, Ng J, Zhang X, Bai H, Sun DD, Colloids Surf. A: Physicochem. Eng. Asp., 379, 169 (2011)
Demirbas A, J. Hazard. Mater., 167(1-3), 1 (2009)
Mohammadi N, Khani H, Gupta VK, Amereh E, Agarwal S, J. Colloid Interface Sci., 362(2), 457 (2011)
Ngah WSW, Hanafiah MAKM, Biochem. Eng. J., 39, 521 (2008)
Masue Y, Loeppert RH, Kramer TA, Environ. Sci. Technol., 41, 837 (2006)

[Referenced By]

[1] Liu T, Li Y, Du Q, Sun J, Jiao Y, Yang G, Wang Z, Xia Y, Zhang W, Wang K, Zhu H, Wu D, Colloids Surf. B: Biointerfaces, 90, 197 (2012)

[2] Atia AA, Donia AM, Al-Amrani WA, Chem. Eng. J., 150(1), 55 (2009)

[3] Fiorentin LD, Trigueros DEG, Modenes AN, Espinoza-Quinones FR, Pereira NC, Barros STD, Santos OAA, Chem. Eng. J., 163(1-2), 68 (2010)

[4] Lau WJ, Ismail AF, Desalination, 245(1-3), 321 (2009)

[5] Sandeman SR, Gun'ko VM, Bakalinska OM, Howell CA, Zheng YS, Kartel MT, Phillips GJ, Mikhalovsky SV, J. Colloid Interface Sci., 358(2), 582 (2011)

[6] Mui ELK, Cheung WH, Valix M, McKay G, J. Colloid Interface Sci., 347(2), 290 (2010)

[7] Liu F, Chung S, Oh G, Seo TS, ACS Appl. Mater. Interfaces, 4, 922 (2011)

[8] Mittal A, Thakur V, Gajbe V, Environ. Sci. Pollut. Res., 19, 2348 (2012)

[9] Huang XX, Qiu LG, Zhang W, Yuan YP, Jiang X, Xie AJ, Shen YH, Zhu JF, Cryst. Eng. Commun., 14, 1613 (2012)

[10] Bai S, Shen X, Zhong X, Liu Y, Zhu G, Xu X, Chen K, Carbon, 50, 2337 (2012)

[11] Khattri SD, Singh MK, Environ. Prog. Sustainable Energy, 31, 435 (2012)

[12] Bhattacharyya R, Ray SK, J. Ind. Eng. Chem., 20(5), 3714 (2014)

[13] Ghaedi M, Ghaedi AM, Hossainpour M, Ansari A, Habibi MH, Asghari AR, J. Ind. Eng. Chem., 20(4), 1641 (2014)

[14] Javadian H, Angaji MT, Naushad M, J. Ind. Eng. Chem., 20(5), 3890 (2014)

[15] Sahoo S, Uma, Banerjee S, Sharma YC, Desalin. Water Treat., 52, 6703 (2014)

[16] Zhang Z, O’Hara IM, Kent GA, Doherty WOS, Ind. Crop. Prod., 42, 41 (2013)

[17] Venkatesha TG, Viswanatha R, Nayaka YA, Chethana BK, Chem. Eng. J., 198-199, 1 (2012)

[18] Luo KQ, Zhou SX, Wu LM, Thin Solid Films, 517(21), 5974 (2009)

[19] Manicone PF, Iommetti PR, Raffaelli L, J. Dent., 35, 819 (2007)

[20] Montgomery DC, Design and Analysis of Experiments, seventh ed., Wiley, New Delhi, 2012.

[21] Anupam K, Dutta S, Bhattacharjee C, Datta S, Chem. Eng. J., 173(1), 135 (2011)

[22] Aydin YA, Aksoy ND, Chem. Eng. J., 151(1-3), 188 (2009)

[23] Gusain D, Srivastava V, Singh VK, Sharma YC, Mater. Chem. Phys., 145(3), 320 (2014)

[24] Singh J, Uma S, Banerjee D, Gusain Y, Sharma C, J. Appl. Sci. Environ. Sanit., 6, 317 (2011)

[25] Singh J, Uma, Banerjee S, Sharma YC, Int. Rev. Chem. Eng., 4, 1 (2012)

[26] Sharma YC, Srivastava V, Weng CH, Upadhyay SN, Can. J. Chem. Eng., 87(6), 921 (2009)

[27] Guo GY, Chen YL, J. Solid State Chem., 178, 1675 (2005)

[28] Goharshadi EK, Hadadian M, Ceram. Int., 38, 1771 (2012)

[29] Deshmane VG, Adewuyi YG, Microporous Mesoporous Mater., 148, 88 (2012)

[30] Tyagi B, Sidhpuria K, Shaik B, Jasra RV, Ind. Eng. Chem. Res., 45(25), 8643 (2006)

[31] Sahu HR, Rao GR, Bull. Mat. Sci., 23, 349 (2000)

[32] Langmuir I, J. Am. Chem. Soc., 40, 1361 (1918)

[33] Xu S, Ng J, Zhang X, Bai H, Sun DD, Colloids Surf. A: Physicochem. Eng. Asp., 379, 169 (2011)

[34] Demirbas A, J. Hazard. Mater., 167(1-3), 1 (2009)

[35] Mohammadi N, Khani H, Gupta VK, Amereh E, Agarwal S, J. Colloid Interface Sci., 362(2), 457 (2011)

[36] Ngah WSW, Hanafiah MAKM, Biochem. Eng. J., 39, 521 (2008)

[37] Masue Y, Loeppert RH, Kramer TA, Environ. Sci. Technol., 41, 837 (2006)