Nanofiltration separation of succinic acid from post-fermentation broth: Impact of process conditions and fouling analysis

Jerzy Antczak; Mateusz Szczygiełda; Krystyna Prochaska

Journal of Industrial and Engineering Chemistry, Vol.77, 253-261, September, 2019

DOI10.1016/j.jiec.2019.04.046 Export Citation

Nanofiltration separation of succinic acid from post-fermentation broth: Impact of process conditions and fouling analysis

Jerzy Antczak, Mateusz Szczygiełda, and Krystyna Prochaska^†

Institute of Chemical Technology and Engineering, Poznan University of Technology, Berdychowo str. 4, 60-965 Poznan, Poland

E-mail:

In this study a pilot-scale setup was used in the nanofiltration (NF) process for recovery of succinic acid from model solutions and the actual post-fermentation broth left after the bioconversion of glycerol. The effects of composition and pH of feed solutions, initial concentration of components and the magnitude of applied transmembrane pressure (TMP) on the separation efficiency, the value of the permeate flux and retention ratio of individual components present in the feed solutions, were investigated. In order to estimate the mechanism of membrane layer fouling formation, the experimental data obtained were compared to the Hermia model.

Keywords:Nanofiltration;Succinic acid;Fermentation broth;Ceramic membrane;Fouling phenomenon;Hermia model

[References]

Werpy T, Petersen G, Top Value Added Chemicals from Biomass, Department of Energy, Washington, DC, pp.31 2004.
Li Q, Wang D, Wu Y, Li WL, Zhang YJ, Xing JM, Su ZG, Sep. Purif. Technol., 72(3), 294 (2010)
Orjuela A, Yanez AJ, Peereboom L, Lira CT, Miller DJ, Sep. Purif. Technol., 83, 31 (2011)
Salvachua D, Mohagheghi A, Smith H, Bradfield MFA, Nicol W, Black AB, Biddy MJ, Dowe N, Beckham GT, Biotechnol. Biofuels, 9, 28 (2016)
Gao C, Yang X, Wang H, Rivero CP, Li C, Cui Z, Qui Q, Lin CSK, Biotechnol. Bioeng., 9, 176 (2016)
Ahn JH, Yang YS, Lee SY, Curr. Opin. Biotechnol., 42, 54 (2016)
Szczygielda M, Antczak J, Prochaska K, Sep. Purif. Technol., 181, 53 (2017)
Thuy NTH, Boontawan A, J. Membr. Sci., 524, 470 (2017)
Huh YS, Jun YS, Hong YK, Song H, Lee SY, Hong WH, Process Biochem., 41(6), 1461 (2006)
Oliveira FS, Araujo JMM, Ferreira R, Rebelo LPN, Marrucho IM, Sep. Purif. Technol., 85, 137 (2012)
Kurzrock T, Weuster-Botz D, Biotechnol. Lett., 32(3), 331 (2010)
Gonzalez MI, Alvarez S, Riera FA, Alvareza R, Desalination, 228(1-3), 84 (2008)
Yang XM, Zhou SY, Li MS, Wang R, Zhao YJ, Sep. Purif. Technol., 175, 435 (2017)
Pateraki C, Ladakis D, Stragier L, Verstraete W, Kookos I, Papanikolau S, Koutinas A, J. Biotechnol., 233, 95 (2016)
Kim JH, Na JG, Shim HJ, Chang YK, J. Membr. Sci., 396, 110 (2012)
Szczygielda M, Prochaska K, J. Membr. Sci., 536, 37 (2017)
Choi JH, Fukushi K, Yamamoto K, Sep. Purif. Technol., 59(1), 17 (2008)
Bastrzyk J, Gryta M, Desalin. Water Treat., 53 (2015)
Kang SH, Chang YK, J. Membr. Sci., 246(1), 49 (2005)
Zaman NK, Rohani R, Shukor MHA, Mohamad AW, Indian J. Sci. Technol., 9, 1 (2016)
Lubsungneon J, Srisuno S, Rodtong S, Boontawan A, J. Membr. Sci., 459, 132 (2014)
Lopez-Garzon CS, Straathof AJJ, Biotechnol. Adv., 32, 873 (2014)
Choi JH, Fukushi K, Yamamoto K, Sep. Purif. Technol., 59(1), 17 (2008)
Wozniak MJ, Prochaska K, Sep. Purif. Technol., 125, 179 (2014)
Li SI, Li C, Liu YS, Wang XL, Cao ZA, J. Membr. Sci., 222(1-2), 191 (2003)
Wang C, Li Q, Tang H, Yan D, Zhou W, Xing J, Wan Y, Biores. Technol., 116, 366 (2012)
Kaya Y, Gonder ZB, Vergili I, Barlas H, Desalination, 250(1), 150 (2010)
Nigam MO, Bansal B, Chen XD, Desalination, 218(1-3), 313 (2008)
Bacchin P, Aimar P, Field RW, J. Membr. Sci., 281(1-2), 42 (2006)
Blanpain-Avet P, Migdal JF, Benezech T, J. Membr. Sci., 337(1-2), 153 (2009)
Ogunbiyi OO, Miles NJ, Hilal N, Desalination, 220(1-3), 273 (2008)
Bae TH, Tak TM, J. Membr. Sci., 249(1-2), 1 (2005)
Schonherr J, Bukovac MJ, J. Agric. Food Chem., 20, 1263 (1972)
Andrade LH, Ricci BC, Grossi LB, Pires WL, Aguiar AO, Amaral MCS, Chem. Eng. J., 323, 545 (2017)
Staszak K, Wozniak M, Sottek M, Karas Z, Prochaska K, J. Chem. Technol. Biotechnol., 1 (2014).
Arsuaga JM, Lopez-Munoz MJ, Aguado J, Sotto A, Desalination, 221(1-3), 253 (2008)
Liu J, Yuan JS, Ji ZY, Wang BJ, Hao YC, Guo XF, Desalination, 390, 53 (2016)
Prochaska K, Staszak K, Wozniak-Budych MJ, Regel-Rosocka M, Adamczak M, Wisniewski M, Staniewski J, Bioresour. Technol., 167, 219 (2014)
Hong SK, Elimelech M, J. Membr. Sci., 132(2), 159 (1997)

[Referenced By]

[1] Werpy T, Petersen G, Top Value Added Chemicals from Biomass, Department of Energy, Washington, DC, pp.31 2004.

[2] Li Q, Wang D, Wu Y, Li WL, Zhang YJ, Xing JM, Su ZG, Sep. Purif. Technol., 72(3), 294 (2010)

[3] Orjuela A, Yanez AJ, Peereboom L, Lira CT, Miller DJ, Sep. Purif. Technol., 83, 31 (2011)

[4] Salvachua D, Mohagheghi A, Smith H, Bradfield MFA, Nicol W, Black AB, Biddy MJ, Dowe N, Beckham GT, Biotechnol. Biofuels, 9, 28 (2016)

[5] Gao C, Yang X, Wang H, Rivero CP, Li C, Cui Z, Qui Q, Lin CSK, Biotechnol. Bioeng., 9, 176 (2016)

[6] Ahn JH, Yang YS, Lee SY, Curr. Opin. Biotechnol., 42, 54 (2016)

[7] Szczygielda M, Antczak J, Prochaska K, Sep. Purif. Technol., 181, 53 (2017)

[8] Thuy NTH, Boontawan A, J. Membr. Sci., 524, 470 (2017)

[9] Huh YS, Jun YS, Hong YK, Song H, Lee SY, Hong WH, Process Biochem., 41(6), 1461 (2006)

[10] Oliveira FS, Araujo JMM, Ferreira R, Rebelo LPN, Marrucho IM, Sep. Purif. Technol., 85, 137 (2012)

[11] Kurzrock T, Weuster-Botz D, Biotechnol. Lett., 32(3), 331 (2010)

[12] Gonzalez MI, Alvarez S, Riera FA, Alvareza R, Desalination, 228(1-3), 84 (2008)

[13] Yang XM, Zhou SY, Li MS, Wang R, Zhao YJ, Sep. Purif. Technol., 175, 435 (2017)

[14] Pateraki C, Ladakis D, Stragier L, Verstraete W, Kookos I, Papanikolau S, Koutinas A, J. Biotechnol., 233, 95 (2016)

[15] Kim JH, Na JG, Shim HJ, Chang YK, J. Membr. Sci., 396, 110 (2012)

[16] Szczygielda M, Prochaska K, J. Membr. Sci., 536, 37 (2017)

[17] Choi JH, Fukushi K, Yamamoto K, Sep. Purif. Technol., 59(1), 17 (2008)

[18] Bastrzyk J, Gryta M, Desalin. Water Treat., 53 (2015)

[19] Kang SH, Chang YK, J. Membr. Sci., 246(1), 49 (2005)

[20] Zaman NK, Rohani R, Shukor MHA, Mohamad AW, Indian J. Sci. Technol., 9, 1 (2016)

[21] Lubsungneon J, Srisuno S, Rodtong S, Boontawan A, J. Membr. Sci., 459, 132 (2014)

[22] Lopez-Garzon CS, Straathof AJJ, Biotechnol. Adv., 32, 873 (2014)

[23] Choi JH, Fukushi K, Yamamoto K, Sep. Purif. Technol., 59(1), 17 (2008)

[24] Wozniak MJ, Prochaska K, Sep. Purif. Technol., 125, 179 (2014)

[25] Li SI, Li C, Liu YS, Wang XL, Cao ZA, J. Membr. Sci., 222(1-2), 191 (2003)

[26] Wang C, Li Q, Tang H, Yan D, Zhou W, Xing J, Wan Y, Biores. Technol., 116, 366 (2012)

[27] Kaya Y, Gonder ZB, Vergili I, Barlas H, Desalination, 250(1), 150 (2010)

[28] Nigam MO, Bansal B, Chen XD, Desalination, 218(1-3), 313 (2008)

[29] Bacchin P, Aimar P, Field RW, J. Membr. Sci., 281(1-2), 42 (2006)

[30] Blanpain-Avet P, Migdal JF, Benezech T, J. Membr. Sci., 337(1-2), 153 (2009)

[31] Ogunbiyi OO, Miles NJ, Hilal N, Desalination, 220(1-3), 273 (2008)

[32] Bae TH, Tak TM, J. Membr. Sci., 249(1-2), 1 (2005)

[33] Schonherr J, Bukovac MJ, J. Agric. Food Chem., 20, 1263 (1972)

[34] Andrade LH, Ricci BC, Grossi LB, Pires WL, Aguiar AO, Amaral MCS, Chem. Eng. J., 323, 545 (2017)

[35] Staszak K, Wozniak M, Sottek M, Karas Z, Prochaska K, J. Chem. Technol. Biotechnol., 1 (2014).

[36] Arsuaga JM, Lopez-Munoz MJ, Aguado J, Sotto A, Desalination, 221(1-3), 253 (2008)

[37] Liu J, Yuan JS, Ji ZY, Wang BJ, Hao YC, Guo XF, Desalination, 390, 53 (2016)

[38] Prochaska K, Staszak K, Wozniak-Budych MJ, Regel-Rosocka M, Adamczak M, Wisniewski M, Staniewski J, Bioresour. Technol., 167, 219 (2014)

[39] Hong SK, Elimelech M, J. Membr. Sci., 132(2), 159 (1997)