Korean Journal of Chemical Engineering, Vol.23, No.6, 965-971, November, 2006
Transient behavior of biofilter inoculated with Thiobacillus sp. IW to treat waste-air containing hydrogen sulfide
E-mail:
Hydrogen sulfide is heavier than air and is colorless, toxic and flammable, the gas odor threshold of which is about 0.47 ppbv, which causes nuisance odor at concentrations as low as about 8ppbv and corrosion problems in sewer systems. The transient behavior of biofilter packed with mixed media (of granular activated carbon and compost) inoculated with a pure culture of Thiobacillus sp. IW was observed at a height of four sampling ports to treat wasteair containing hydrogen sulfide in this investigation, which shall be used as control to be compared with the performance of a biofilter-involved integrated system for the treatment of waste-air containing hydrogen sulfide in a subsequent investigation. Unlike the previous studies of the other investigators, various process conditions were applied to successive biofilter runs in order to monitor and correlate each corresponding unsteady behavior of the biofilter at the height of each sampling port. During 10 days (20 times) after start-up of a biofilter hydrogen sulfide was continuously adsorbed on the media and that the adsorption of hydrogen sulfide was under way since the inlet loads of 1st and 2nd stage operations were very low. Afterwards it was obvious that the breakthrough curves at the 1st, 2nd, 3rd and 4th (exit) sampling ports responded rapidly to the change of operating conditions of a biofilter so that the breakthrough curve at each sampling port responded rapidly to approach a new state of saturation, which suggests that the adsorption capacity of biofilter-media may be relatively small or its affinity to hydrogen sulfide may be relatively high, compared to such volatile organic compound as ethanol. Up to the 3rd stage of operation the removal efficiency continued to be nearly 100%. However it began to decrease as inlet load increased. At the end of last stage of the biofilterrun removal efficiency was decreased and maintained at 94%. The maximum elimination capacity was observed to be ca. 95 g/m3/h, which was higher than that of the biofiltration-work of any other previous investigator except for that of the biofiltration-work with use of each of two inorganic packing materials (porous ceramics, calcinated and formed obsidian).
- Buisman CJ, Geraats BG, Ljspeert P, Lettinga G, Biotechnol. Bioeng., 35, 50 (1990)
- Cho KS, Ryu HW, Lee NY, J. Biosci. Bioeng., 90(1), 25 (2000)
- Chung YC, Huang CP, Tseng CP, Biotechnol. Prog., 12(6), 773 (1996)
- Chung YC, Huang C, Tseng CP, J. Biotechnol., 52, 31 (1996)
- Chung YC, Huang C, Tseng CP, Chemosphere, 43, 1043 (2001)
- Cox HHJ, Deshusses MA, Chem. Eng. J., 87(1), 101 (2002)
- Eckhart A, Proceedings of biological treatment of industrial waste gases, Dechema, Heidelberg, Germany, Mar. 24-26, 2pp (1987)
- Elias A, Barona A, Arreguy A, Rios J, Aranguiz I, Penas J, Process Biochem., 37, 813 (2002)
- Hirai M, Kamamoto M, Yani M, Shoda M, J. Biosci. Bioeng., 91(4), 396 (2001)
- Hirai M, Ohtake M, Shoda M, J. Ferment. Bioeng., 70, 334 (1990)
- Islander RI, Devinny JS, Mansfield F, Postyn A, Shin H, J. Environ. Eng., 117, 751 (1990)
- Lee TJ, Kwon OY, An SJ, J. KSEE, 22, 1601 (2000)
- Lim KH, Lee EJ, Korean J. Chem. Eng., 20(2), 315 (2003)
- Lim KH, Park SW, Korean J. Chem. Eng., 21(6), 1161 (2004)
- Lim KH, Korean J. Chem. Eng., 22(2), 228 (2005)
- Ottengraf SPP, Exhaust gas purification, Biotechnology (H. J. Rehm, G. Reed, eds), VCH, Weinheim, Germany, Vol. 8, pp.426-452 (1986)
- Oyarzun P, Arancibia F, Canales C, Aroca GE, Process Biochem., 1 (2003)
- Sorial GA, Smith FL, Suidan MT, Biswas P, Journal of the Air & Waste Management Association, 45, 801 (1995)
- Wani AH, Branion MR, Lau AK, J. Hazard. Mater., 60, 287 (1998)