A membrane desalination system based on electrodialysis reversal (EDR) has been evaluated for its capacity to remove salt from treated municipal wastewater to provide a source of recycled water for horticultural applications. Economic and technical feasibility was determined using data collected from a pilot scale plant, from which the following parameters were calculated: salt removal, water recovery and overall process economics. The pilot plant consisted of a pre-treatment multimedia filtration unit (MMF) and an EDR system with a capacity of approximately 144 kL/day. Treated effluent from a wastewater treatment plant (WWTP) was used as feed water for the desalination pilot plant. Water quality guidelines for horticulture specify an upper limit for total dissolved solids (TDS) of 375 mg/L. The EDR process reduced the TDS from 1104 mg/L to 328 mg/L. Additionally, the process reduced the conductivity of recycled water by 72%, including the removal of 84% calcium, 76% chloride, 59% fluoride, 64% alkalinity and 60% phosphate, demonstrating that the EDR treated water is a viable alternative supply. The power consumption of the EDR plant was found to be 0.6 kW h/kL and the media filtration 0.4 kW/kL. The total operating cost was estimated to be 18 cents/kL to deliver 82% water recovery. (C) 2013 Elsevier B.V. All rights reserved,