화학공학소재연구정보센터
홈 로그인 로그아웃 연락처 사이트맵
Journal of Industrial and Engineering Chemistry, Vol.20, No.4, 1761-1764, July, 2014
DOI10.1016/j.jiec.2013.08.029  Export Citation
Synthesize of polyaniline-multi walled carbon nanotubes composite on the glass and silicon substrates and methane gas sensing behavior of them at room temperature
S. Sattari, A. Reyhani†, M.R. Khanlari, M. Khabazian1, and H. Heydari
  • Physics Department, Faculty of Science, Imam Khomeini International University, P.O. Box: 34149-16818, Qazvin, Iran
  • 1Chemical Engineering Department, Polymer Group, Tarbiat Modares University, P.O. Box: 14115-114, Tehran, Iran
E-mail:
In this study, fabrication of methane gas sensor using composites of multi-walled carbon nanotubes (MWCNT) and polyaniline (PANI) on glass and silicon substrates is reported. In this respect, 8 wt% of purified MWCNT by acid washing procedure, was combined with PANI by solution mixing method. The MWCNT-PANI composite was deposited on the surface of glass and Si substrates using spin coating technique. The methane gas sensing of composite films were evaluated by measuring the change of electrical resistance in the presence of methane gas at room temperature. It is observed that the MWCNT-PANI film on the Si substrate shows a higher sensitivity to methane gas in comparison to pure PANI on the glass substrate. The characterization of samples has also been investigated by Fourier transform infrared, transmission electron microscopy and scanning electron microscopy analyses.
Keywords:Multi-walled carbon nanotubes;Purification;Polyaniline;Methane gas sensing
  1. Srivastava S, Sharma SS, Kumar S, Agrawal S, Singh M, Vijay YK, Int. J. Hydrog. Energy, 34(19), 8444 (2009)
  2. Li Z, Li J, Wu X, Shuang S, Dong C, Choi MMF, Sens. Actuators B-Chem., 139, 453 (2009)
  3. Wen G, Zheng J, Zhao C, Shuang S, Dong C, Choi MMF, Enzyme Microb. Technol., 43(3), 257 (2008)
  4. Chakraborty S, Sen A, Maiti HS, Sens. Actuators B-Chem., 115, 610 (2006)
  5. Bhattacharyya P, Basu PK, Saha H, Basu S, Sens. Actuators B-Chem., 124, 62 (2007)
  6. Matveev B, Aidaraliev M, Gavrilov G, Zotova N, Karandashov S, Sotnikova C, et al., Sens. Actuators B-Chem., 51, 233 (1998)
  7. Lucchesini A, Gozzini S, J. Quant. Spectrosc. Radiat. Trans., 103, 209 (2007)
  8. Abbaszadeh D, Ghasempour R, Rahimi F, Iraji zad A, Sens. Transduc. J., 73, 819 (2006)
  9. Li Y, Wang H, Chen Y, Yang M, Sens. Actuators B-Chem., 132, 155 (2008)
  10. Bhadra S, et al., Prog. Polym. Sci, 34, 783 (2009)
  11. Nicolas-Debarnot D, Poncin-Epaillard F, Anal. Chim. Acta, 475, 1 (2003)
  12. Li ZP, Zhang JL, Zhou YH, Shuang SM, Dong C, Choi MMF, Electrochim. Acta, 76, 288 (2012)
  13. Jun JH, Yun J, Cho KI, Hwang SJ, Lee H, Kim S, Sens. Actuators B-Chem., 140, 412 (2009)
  14. Barazzouk S, Tandon RP, Hotchandani S, Sens. Actuators B-Chem., 119, 691 (2006)
  15. Xi LJ, Qian D, Tang XC, Chen CJ, Mater. Chem. Phys., 108(2-3), 232 (2008)
  16. Hu P, Du G, Zhou W, Cui Z, Lin J, Liu H, Liu D, Wang J, Chen S, Appl. Mater. Interf., 2, 3263 (2010)
  17. Fidelus JD, Lojkowski W, Millers D, Grigorjeva L, Smits K, Piticescu RR, Solid State Phenom., 128, 141 (2007)
  18. Satyanarayana L, Gopal Reddy CV, Manorama SV, Rao VJ, Sens. Actuators B-Chem., 46, 1 (1998)
  19. MacDiarmid AG, Chiang JC, Richter AF, Epstein AJ, Polyaniline Synth. Met, 18, 285 (1987)
  20. Focke WW, Wnek GE, Wei Y, J. Phys. Chem., 91, 5813 (1987)
  21. Cao Y, Andreatta A, Heeger AJ, Smith P, Polymer, 30, 2305 (1989)
  22. Panigrahi M, Majumdar SB, Adhikari B, H3PO4-doped DL.PLA/PANI conductive composite for methane gas sensing, IEEE, (2011), pp. 1.7.
  23. Macdiarmid AG, Chiang JC, Richter AF, Epstein AJ, Synth. Met., 18, 285 (1987)
  24. Ray A, Asturias GE, Kershner DL, Richter AF, MacDiarmid AG, Epstein AJ, Synth. Met., 29, 141 (1989)
  25. Agbor NE, Petty MC, Monkman AP, Sens. Actuators B-Chem., 28, 173 (1995)
  26. Reyhani A, Mortazavi SZ, Mirershadi S, Moshfegh AZ, Parvin P, Golikand AN, J. Phys. Chem. C, 115, 6994 (2011)
  27. Reyhani A, Mortazavi SZ, Moshfegh AZ, Golikand AN, Int. J. Hydrog. Energy, 35(1), 231 (2010)
  28. Tzeng Y, Chen Y, Liu C, Diam. Relat. Mat., 12, 442 (2003)
  29. Li WZ, Liang CH, Zhou WJ, Qiu JS, Zhou ZH, Sun GQ, Xin Q, J. Phys. Chem. B, 107(26), 6292 (2003)
  30. Reyhani A, Mortazavi SZ, Moshfegh AZ, Golikand AN, Amiri M, J. Power Sources, 188(2), 404 (2009)
  31. Li YH, Zhao YM, Zhu YQ, Rodriguez J, Morante JR, Mendoza E, et al., Carbon, 44, 1821 (2006)
  32. Valentini L, Armentano I, Kenny JM, Cantalini C, Lozzi L, Santucci S, J. Appl. Phys. Lett., 82, 961 (2003)
  33. Valentini L, Cantalini C, Armentano I, Kenny JM, Lozzi L, Santucci S, Diam. Relat. Mat., 13, 1301 (2004)
  34. Mirershadi S, Mortazavi Z, Reyhani A, Moniri N, Novinrooz AJ, 2th International conference of sciences and Nanotechnology, Tbriz University, Iran, 2008.
  35. Mirershadi S, Mortazavi SZ, Reyhani A, Moniri N, Novinrooz AJ, Synth. React. Inorg. Met., 39, 204 (2009)
  36. Jung YC, So HH, Cho JW, J. Korea Phys. Soc., 51, S1 (2007)
  37. Stobinski L, Lesiak B, Kver L, Tth J, Biniak S, Trykowski G, Judek J, J. Alloy. Compd., 501, 77 (2010)
  38. Safibonab B, Reyhani A, Golikand AN, Mortazavi SZ, Mirershadi S, Ghoranneviss M, Appl. Surf. Sci., 258(2), 766 (2011)
  39. Ghasempour R, Mortazavi SZ, Zad AI, Rahimi F, Int. J. Hydrog. Energy, 35(9), 4445 (2010)
  40. Niu L, Luo Y, Li Z, Sens. Actuators B-Chem., 126, 361 (2007)
  41. Chen GX, Kim HS, Park BH, Yoon JS, Polymer, 47(13), 4760 (2006)
  42. Dong Z, Yang B, Jin J, Li J, Kang H, Zhong X, Li R, Ma J, Nanoscale Res. Lett., 4, 335 (2009)
  43. Rimbu A, Stamatin I, Jackson CL, Scott K, Adv. Mater., 8, 670 (2006)
  44. Chauhan NPS, Ameta R, Ameta R, Ameta SC, Indian J. Chem. Technol., 18(2), 118 (2011)
  45. Lu YJ, Li J, Han J, Ng HT, Binder C, Partridge C, Meyyappan M, Chem. Phys. Lett., 391(4-6), 344 (2004)