Effect of carbon nanotube addition on friction coefficient of nanotubes/hydroxyapatite composites

Qian Zhao; Yalong Shen; Meiru Ji; Lei Zhang; Tingshun Jiang; Cangsheng Li

Journal of Industrial and Engineering Chemistry, Vol.20, No.2, 544-548, March, 2014

DOI10.1016/j.jiec.2013.04.040 Export Citation

Effect of carbon nanotube addition on friction coefficient of nanotubes/hydroxyapatite composites

Qian Zhao^†, Yalong Shen, Meiru Ji, Lei Zhang, Tingshun Jiang, and Cangsheng Li

School of Chemistry and Chemical Engineering, Jiangsu University, Zhenjiang 212013, Jiangsu, China

E-mail:

Carbon nanotubes/hydroxyapatite (CNTs/HA) composites with different CNTs contents were synthe-sized by in situ method and were characterized by XRD, TEM and Raman spectroscopy. Friction coefficients of the composites were tested using UMT-2 friction tester. Effect of various factors including CNTs content, testing time and applied load on friction coefficient was carried out. Results show that the CNTs/HA composites exhibited lower friction coefficient than pure HA and their friction coefficients decreased with increase of CNTs content from 0 to 20 wt.%. Addition of CNTs in composite is beneficial to increase wear resistance of the CNTs/HA composite and to decrease its friction coefficient.

Keywords:Carbon nanotubes/hydroxyapatite;composite;Carbon nanotubes;Hydroxyapatite;Characterization;Friction coefficient

[References]

Mangood A, Malkaj P, Dalas E, J. Cryst. Growth, 290(2), 565 (2006)
Lin X, Leng Y, Biomaterials, 26, 1097 (2005)
Xin RL, Leng Y, Wang N, J. Cryst. Growth, 289(1), 339 (2006)
Salem A, Velayi E, J. Ind. Eng. Chem., 18(4), 1216 (2012)
Gross KA, Berndt CC, J. Biomed. Mater. Res. B, 39, 1998 (580)
Hench LL, J. Am. Ceram. Soc., 81, 1705 (1998)
Hirai T, Hodono M, Komasawa I, Langmuir, 16(3), 955 (2000)
Kong DJ, Long D, Wu YZ, Zhou CZ, Transactions of Nonferrous Metals Society of China, 22, 104 (2012)
Guo YP, Yao YB, Ning CQ, Chu LF, Guo YJ, Mater. Lett., 65, 1007 (2011)
Chang CY, Peng N, He M, Teramoto Y, Nishio Y, Zhang L, Carbohydr. Polym., 91, 7 (2013)
Suchanek W, Yoshimara M, J. Mater. Res., 13, 94 (1998)
Hu H, Ni YC, Montana V, Haddon RC, Parpura V, Nano Lett., 4, 507 (2004)
Peterlik H, Roschger P, Klaushofer K, Fratzl P, Nat. Mater., 5(1), 52 (2006)
Chiu CH, Hsu HC, Tuan WG, Ceram. Int., 33, 715 (2007)
Iijima S, Nature, 354, 56 (1991)
Ahn CH, Baek Y, Lee C, Kim SO, Kim S, Lee S, Kim SH, Bae SS, Park J, Yoon J, J. Ind. Eng. Chem., 18(5), 1551 (2012)
Liu JX, Zhou WJ, Gong JL, Tang L, Zhang Y, Yu HY, Wang B, Xu XM, Zeng GM, Bioresour. Technol., 99(18), 8748 (2008)
Zhang MG, Gorski W, J. Am. Chem. Soc., 127(7), 2058 (2005)
Cipriano BH, Kota AK, Gershon AL, Laskowski CJ, Kashiwagi T, Bruck HA, Raghavan SR, Polymer, 49(22), 4846 (2008)
Mondal KC, Strydom AM, Erasmus RM, Keartland JM, Coville NJ, Mater. Chem. Phys., 111(2-3), 386 (2008)
Coleman JN, Khan U, Gun'ko YK, Adv. Mater., 18(6), 689 (2006)
Asuri P, Karajanagi SS, Dordick JS, Kane RS, J. Am. Chem. Soc., 128(4), 1046 (2006)
Reyhani A, Mortazavi SZ, Golikand AN, Moshfegh AZ, Mirershadi S, J. Power Sources, 183(2), 539 (2008)
Reddy ALM, Ramaprabhu S, Int. J. Hydrog. Energy, 32(16), 3998 (2007)
Yu MF, Files BS, Arepalli S, Ruoff RS, Phys. Rev. Lett., 84, 5552 (2000)
Cha SI, Kim KT, Lee KH, Mo CB, Jeng YJ, Hong SH, Carbon, 46, 482 (2008)
Im JS, Lee SK, Yun J, Lee YS, J. Ind. Eng. Chem., 18(3), 1023 (2012)
Li HP, Wang LH, Liang CY, Wang ZF, Zhao WM, Mater. Sci. Eng. B, 166, 19 (2010)
Lee HH, Shin US, Won JE, Kim HW, Mater. Lett., 65, 208 (2011)
Xiao X, Gong T, Zhou SB, Biomaterials, 31, 5182 (2010)
Aryal S, Bahadur KCR, Dharmaraj N, Kim KW, Kim HY, Scr. Mater., 54, 131 (2006)
Zhao HY, Xu XX, Zhang JX, Zheng W, Zheng YF, Bio. Electro. Chem., 78, 124 (2010)
Liu ZG, Chen L, Zhang ZC, Li YY, Dong YH, Sun YB, J. Mol. Liq., 179, 46 (2013)
Meng YH, Tang CY, Tsui CP, Chen DZ, J. Mater. Sci. -Mater. Med., 19, 75 (2008)
Zhao Q, Li YH, Zhou XP, Jiang TS, Li CS, Yin HB, Superlattices Microstruct., 97-98, 822 (2001)
Boolchand P, Jin MJ, Novita DI, Chakravarty S, J. Raman Spectrosc., 38, 660 (2007)
Popovic´ L, Waal D, Boeyens JCA, J. Raman Spectrosc., 36, 2 (2005)
Liao SS, Xu GF, Wang W, Watari F, Cui FZ, Ramakrishna S, Chan CK, Acta Biomaterialia., 3, 669 (2007)
Chen XH, Chen CS, Xiao HN, Liu HB, Zhou LP, Li SL, Zhang G, Trib, 39, 22 (2006)
Lim DS, You DH, Choi HJ, Lim SH, Jang H, Wear, 259, 539 (2005)
Gong QM, Li Z, Zhang ZY, Wu B, Zhou XW, Huang QZ, Liang J, Trib, 39, 937 (2006)

[Referenced By]

[1] Mangood A, Malkaj P, Dalas E, J. Cryst. Growth, 290(2), 565 (2006)

[2] Lin X, Leng Y, Biomaterials, 26, 1097 (2005)

[3] Xin RL, Leng Y, Wang N, J. Cryst. Growth, 289(1), 339 (2006)

[4] Salem A, Velayi E, J. Ind. Eng. Chem., 18(4), 1216 (2012)

[5] Gross KA, Berndt CC, J. Biomed. Mater. Res. B, 39, 1998 (580)

[6] Hench LL, J. Am. Ceram. Soc., 81, 1705 (1998)

[7] Hirai T, Hodono M, Komasawa I, Langmuir, 16(3), 955 (2000)

[8] Kong DJ, Long D, Wu YZ, Zhou CZ, Transactions of Nonferrous Metals Society of China, 22, 104 (2012)

[9] Guo YP, Yao YB, Ning CQ, Chu LF, Guo YJ, Mater. Lett., 65, 1007 (2011)

[10] Chang CY, Peng N, He M, Teramoto Y, Nishio Y, Zhang L, Carbohydr. Polym., 91, 7 (2013)

[11] Suchanek W, Yoshimara M, J. Mater. Res., 13, 94 (1998)

[12] Hu H, Ni YC, Montana V, Haddon RC, Parpura V, Nano Lett., 4, 507 (2004)

[13] Peterlik H, Roschger P, Klaushofer K, Fratzl P, Nat. Mater., 5(1), 52 (2006)

[14] Chiu CH, Hsu HC, Tuan WG, Ceram. Int., 33, 715 (2007)

[15] Iijima S, Nature, 354, 56 (1991)

[16] Ahn CH, Baek Y, Lee C, Kim SO, Kim S, Lee S, Kim SH, Bae SS, Park J, Yoon J, J. Ind. Eng. Chem., 18(5), 1551 (2012)

[17] Liu JX, Zhou WJ, Gong JL, Tang L, Zhang Y, Yu HY, Wang B, Xu XM, Zeng GM, Bioresour. Technol., 99(18), 8748 (2008)

[18] Zhang MG, Gorski W, J. Am. Chem. Soc., 127(7), 2058 (2005)

[19] Cipriano BH, Kota AK, Gershon AL, Laskowski CJ, Kashiwagi T, Bruck HA, Raghavan SR, Polymer, 49(22), 4846 (2008)

[20] Mondal KC, Strydom AM, Erasmus RM, Keartland JM, Coville NJ, Mater. Chem. Phys., 111(2-3), 386 (2008)

[21] Coleman JN, Khan U, Gun'ko YK, Adv. Mater., 18(6), 689 (2006)

[22] Asuri P, Karajanagi SS, Dordick JS, Kane RS, J. Am. Chem. Soc., 128(4), 1046 (2006)

[23] Reyhani A, Mortazavi SZ, Golikand AN, Moshfegh AZ, Mirershadi S, J. Power Sources, 183(2), 539 (2008)

[24] Reddy ALM, Ramaprabhu S, Int. J. Hydrog. Energy, 32(16), 3998 (2007)

[25] Yu MF, Files BS, Arepalli S, Ruoff RS, Phys. Rev. Lett., 84, 5552 (2000)

[26] Cha SI, Kim KT, Lee KH, Mo CB, Jeng YJ, Hong SH, Carbon, 46, 482 (2008)

[27] Im JS, Lee SK, Yun J, Lee YS, J. Ind. Eng. Chem., 18(3), 1023 (2012)

[28] Li HP, Wang LH, Liang CY, Wang ZF, Zhao WM, Mater. Sci. Eng. B, 166, 19 (2010)

[29] Lee HH, Shin US, Won JE, Kim HW, Mater. Lett., 65, 208 (2011)

[30] Xiao X, Gong T, Zhou SB, Biomaterials, 31, 5182 (2010)

[31] Aryal S, Bahadur KCR, Dharmaraj N, Kim KW, Kim HY, Scr. Mater., 54, 131 (2006)

[32] Zhao HY, Xu XX, Zhang JX, Zheng W, Zheng YF, Bio. Electro. Chem., 78, 124 (2010)

[33] Liu ZG, Chen L, Zhang ZC, Li YY, Dong YH, Sun YB, J. Mol. Liq., 179, 46 (2013)

[34] Meng YH, Tang CY, Tsui CP, Chen DZ, J. Mater. Sci. -Mater. Med., 19, 75 (2008)

[35] Zhao Q, Li YH, Zhou XP, Jiang TS, Li CS, Yin HB, Superlattices Microstruct., 97-98, 822 (2001)

[36] Boolchand P, Jin MJ, Novita DI, Chakravarty S, J. Raman Spectrosc., 38, 660 (2007)

[37] Popovic´ L, Waal D, Boeyens JCA, J. Raman Spectrosc., 36, 2 (2005)

[38] Liao SS, Xu GF, Wang W, Watari F, Cui FZ, Ramakrishna S, Chan CK, Acta Biomaterialia., 3, 669 (2007)

[39] Chen XH, Chen CS, Xiao HN, Liu HB, Zhou LP, Li SL, Zhang G, Trib, 39, 22 (2006)

[40] Lim DS, You DH, Choi HJ, Lim SH, Jang H, Wear, 259, 539 (2005)

[41] Gong QM, Li Z, Zhang ZY, Wu B, Zhou XW, Huang QZ, Liang J, Trib, 39, 937 (2006)